48 Volt Club Car Lynx Stops Running and Only Clicks

C

CEDARBUCK

New Member
I have 2008 Club Car Lynx IQ CAMO 48 Volt. When we would ride it would go fine for 10-15 minutes then quit. I would let it sit for a few minutes and we could go again for a short period of time.Last week we were riding and it quit and will not go again. Batteries are charged and when you push pedal down I hear a click.Looking for advice. Thanks.
 
C

CEDARBUCK

New Member
Just took cover off controller area and bottom post on controller melted.Wondering what coul have caused this.
 
HotRodCarts

HotRodCarts

Cartaholic
Welcome to the forum.
Usually it would be from a bad cable or bad cable connection at the terminal that melted.
 
C

CEDARBUCK

New Member
Thanks for replies. Should I replace with same 350 amp controller or go larger. Also my battery cables are 6 gauge. Is it necessary to convert to 4 gauge cables?
 
HotRodCarts

HotRodCarts

Cartaholic
It all depends on what you plan to use the cart for. Is the cart lifted with big tires? If not 350 amps should be fine. I would put a complete GOOD set of 4 gauge cables on it though.
 
S

shadowman

New Member
its not gonna hurt to upgrade controller and yes you should go with 4 gage cables thurout cart...............................
cool.gif
 
HotRodCarts

HotRodCarts

Cartaholic
I would check with Allsports, Everything Carts or Buggies Unlimited. Their links are at the top of the pages here.
 
You must log in or register to reply here.
Top