ezgo

  1. HotRodCarts

    E-Z-GO 295 Cam Timing Diagram

    E-Z-GO 295 Cam Timing Diagram EZGO Cam Timing Diagram - E-Z-GO Medalist and EZGO TXT Robin 295 Engine
  2. HotRodCarts

    E-Z-GO Brake Job

    EZGO Golf Cart Brake Job How To First jack it up and place on stands safety is always first. Take the lugs loose and remove wheel & tire. Now for the fun part: First take the cable loose from the brake lever on the back side of the backing plate. Once this is loose work the brake lever back...
  3. HotRodCarts

    E-Z-GO Valve Adjustment

    EZGO Golf Cart Valve Adjustment Start with a cold engine. Remove 6 valve cover bolts, and pry off cover: Clean o-ring surface(blue arrows) carefully. Do not drop dirt in any holes. Check o-ring for damage, and make sure it is fully seated in cover(red arrows). Do this now, you'll be too...
  4. HotRodCarts

    E-Z-GO PDS Electric Diagnostic Mode

    EZGO PDS Golf Cart Diagnostic Mode E-Z-GO PDS Diagnostic Mode: To place the E-Z-GO PDS Golf Cart in diagnostic mode, with the key in the 'OFF' position, move the 'Run Tow Maintenance' switch to the 'RUN' position, move the Forward and Reverse switch from 'Neutral to Reverse' five times... The...
  5. HotRodCarts

    E-Z-GO PDS Fault Codes

    EZGO PDS Golf Cart Diagnostic Mode & Fault Codes E-Z-GO PDS Diagnostic Mode - EZGO PDS Fault Diagnostic Codes To place the E-Z-GO PDS Golf Cart in diagnostic mode, with the key in the 'OFF' position, move the 'Run Tow Maintenance' switch to the 'RUN' position, move the Forward and Reverse...
  6. HotRodCarts

    E-Z-GO TXT Golf Cart Cables Lengths - Electric

    EZGO TXT Fleet Golf Cart Cable Lengths Controller B- to Battery pack Negative 36" Controller M- to Motor A1 55" Solenoid to Battery pack Positive 27" Shifter C to Motor A2 44" Shifter B to Motor S2 41" Shifter D to Motor S1 46" Shifter A to Controller B+ 24" Solenoid to Controller B+ 6"...
  7. HotRodCarts

    E-Z-GO - Reed Switch Test and Bypass

    EZGO Golf Cart Reed Switch Testing and Bypass Check for battery pack voltage at the small white wire coming out of the back of the charger receptacle. If there's no voltage reading the reed switch is blown. You can unplug the connector on the red/white wire and run a jumper from the red wire on...
  8. HotRodCarts

    E-Z-GO - Powerwise Charger Diagram

    EZGO - Powerwise Golf Cart Battery Charger - Wiring Diagram
  9. HotRodCarts

    Preventive and Routine Maintenance

    EZGO Golf Cart Preventive and Routine Maintenance - GAS Throttle Cable Adjustment: Adjustment: To adjust the throttle cable, check to ensure the throttle plate is fully closed and governor arm is rotated fully counter-clockwise. By the throttle cable bracket are two nuts (1/2 inch). Loosen...
  10. HotRodCarts

    E-Z-GO 4 Stroke Engine Diagram

    E-Z-GO Golf Cart Engine Diagram
Top