Club Car Gas Diagrams
Club Car Gas Golf Cart Wiring Diagrams, Repair Diagrams, Troubleshooting Diagrams, Service Manuals
-
Resource icon
Resource 'Club Car Service Manual for FE290 and FE350 Kawasaki Engines'
Club Car Service Manual for FE290 and FE350 Kawasaki Engines Kawasaki FE120, FE170, FE250, FE290, FE350, FE400 Club Car Service Manual Club Car FE-290 and FE-350 Kawasaki Engine Service Manual :clubcar: Club Car Service Manual for Kawasaki Engines- HotRodCarts
- Updated:
-
Resource icon
Resource 'Club Car Gas Valve Lash Adjusting'
Adjusting Valves on a Club Car Golf Cart Does your engine have a "ticking" sound? It could mean its time for a valve adjustment. Before starting anything make sure the key is off and the battery disconnected. Remove the two 10mm bolts that hold the valve cover on. Remove the valve cover. To find top dead center, remove the spark plug and insert a straw or a small dowel rod. DO NOT use a screw driver. You could possibly scratch the cylinder if you are new to this. Rotate the clutch until...- HotRodCarts
- Updated:
-
Resource icon
Resource 'Club Car DS Servicing'
This post is about how to service your gas Club Car DS gas models 1992-2005 with the FE290cc engine and most FE350cc models. :clubcar: ENGINE OIL AND FILTER CHANGE First, lets start with the basic oil & filter change. This should work with both a lifted cart and a non lifted cart. Since a lot of people are now lifting their car, it tends to tilt the engine cradle in such a way that it is hard to drain all the oil out. So the first thing to do is: 1: Take your cart...- HotRodCarts
- Updated:
-
Resource icon
Resource 'EZGO Gas Golf Cart Valve Lash Adjusting'
EZGO Golf Cart Valve Lash Adjustment - EZGO TXT and EZGO Marathon :ezgo: Start with a cold engine. Remove 6 valve cover bolts, and pry off cover: Clean o-ring surface(blue arrows) carefully. Do not drop dirt in any holes. Check o-ring for damage, and make sure it is fully seated in cover(red arrows). Do this now, you'll be too excited later, and forget: Pick a valve. Turn cam lobe DOWN by rotating drive clutch by hand(red arrow): Loosen adjuster locknut 1/4-1/2 turn. Insert .004"...- HotRodCarts
- Updated:
10 Amp Fuse Location on a Club Car Precedent Gas Golf Cart
Front Suspension Parts Diagrams for Mid 90's Club Car DS Models
Installing Snubber on a Club Car Gas Golf Cart
2001 Club Car DS Gas Golf Cart Wiring Diagram - Turf 1 - Carryall 1 - Villager 4
Instructions For Removing a Club Car Gas Engine - FE290
Adjusting a Club Car Governor and Throttle Cable
- Featured
Club Car Service Manual for FE290 and FE350 Kawasaki Engines PDF Download
- Featured
Club Car DS Engine Oil and Rear End Oil Change | Air Filter, Spark Plug Replacement