Resources
-
Resource icon
Resource 'Club Car Service Manual for FE290 and FE350 Kawasaki Engines'
Club Car Service Manual for FE290 and FE350 Kawasaki Engines Kawasaki FE120, FE170, FE250, FE290, FE350, FE400 Club Car Service Manual Club Car FE-290 and FE-350 Kawasaki Engine Service Manual :clubcar: Club Car Service Manual for Kawasaki Engines- HotRodCarts
- Updated:
-
Resource icon
Resource 'Club Car Gas Valve Lash Adjusting'
Adjusting Valves on a Club Car Golf Cart Does your engine have a "ticking" sound? It could mean its time for a valve adjustment. Before starting anything make sure the key is off and the battery disconnected. Remove the two 10mm bolts that hold the valve cover on. Remove the valve cover. To find top dead center, remove the spark plug and insert a straw or a small dowel rod. DO NOT use a screw driver. You could possibly scratch the cylinder if you are new to this. Rotate the clutch until...- HotRodCarts
- Updated:
-
Resource icon
Resource 'Club Car DS Servicing'
This post is about how to service your gas Club Car DS gas models 1992-2005 with the FE290cc engine and most FE350cc models. :clubcar: ENGINE OIL AND FILTER CHANGE First, lets start with the basic oil & filter change. This should work with both a lifted cart and a non lifted cart. Since a lot of people are now lifting their car, it tends to tilt the engine cradle in such a way that it is hard to drain all the oil out. So the first thing to do is: 1: Take your cart...- HotRodCarts
- Updated:
-
Resource icon
Resource 'EZGO Gas Golf Cart Valve Lash Adjusting'
EZGO Golf Cart Valve Lash Adjustment - EZGO TXT and EZGO Marathon :ezgo: Start with a cold engine. Remove 6 valve cover bolts, and pry off cover: Clean o-ring surface(blue arrows) carefully. Do not drop dirt in any holes. Check o-ring for damage, and make sure it is fully seated in cover(red arrows). Do this now, you'll be too excited later, and forget: Pick a valve. Turn cam lobe DOWN by rotating drive clutch by hand(red arrow): Loosen adjuster locknut 1/4-1/2 turn. Insert .004"...- HotRodCarts
- Updated:
Diagram for EZGO Robin 295 Timing Mark Alignment
Testing a Club Car Motor Speed Sensor
Wiring Diagrams for 2018 Club Car Onward Gas Golf Cart
Wiring Diagram for ICON Electric Vehicles
Front Suspension Diagran for Club Car DS Gas and Electric
Diagrams for Setting Timing on a EZGO 2 Stroke
Wiring Diagrams for Gas EZGO Valor EFI
Service Manuals and Part Manuals for Cushman and E-Z-GO Carts
10 Amp Fuse Location on a Club Car Precedent Gas Golf Cart
Wiring Diagram for Cushman Electric Golf Cart
Wiring Diagram for Cushman Gas Golf Cart
Front Suspension Parts Diagrams for Mid 90's Club Car DS Models
Axle Alignment for EZGO TXT, Medalist and Marathon Gas and Electric Golf Carts
EZGO RXV Electric Golf Cart Rear End Oil Change
Wiring Diagram for a Melex 512E Electric Golf Cart
Service Manual for 1986-1988 Columbia Gas Golf Cart
Installing Snubber on a Club Car Gas Golf Cart
Service and Owners Manual for a EZGO ST-350